Space Shuttle Challenger disaster Space Shuttle Challenger's smoke plume after its in-flight breakup, resulting in its crash and the deaths of all seven crew members. Date January28,1986(1986-01-28) Time 11:39:13 EST (16:39:13 UTC) Location Atlantic Ocean, off the coast of central Florida Outcome Grounding of the Space Shuttle fleet for nearly three years during which various safety measures, solid rocket booster redesign, and a new policy on management decision-making for future launches were implemented. Casualties Francis R. Scobee, Commander Michael J. Smith, Pilot Ronald McNair, Mission Specialist Ellison Onizuka, Mission Specialist Judith Resnik, Mission Specialist Greg Jarvis, Payload Specialist Christa McAuliffe, Payload Specialist Inquiries Rogers Commission
The Space Shuttle Challenger disaster occurred on January 28, 1986, when Space Shuttle Challenger (mission STS-51-L) broke apart 73 seconds into its flight, leading to the deaths of its seven crew members. The spacecraft disintegrated over the Atlantic Ocean, off the coast of central Florida at 11:38 EST (16:38 UTC). Disintegration of the vehicle began after an O-ring seal in its right solid rocket booster (SRB) failed at liftoff. The O-ring failure caused a breach in the SRB joint it sealed, allowing pressurized hot gas from within the solid rocket motor to reach the outside and impinge upon the adjacent SRB attachment hardware and external fuel tank. This led to the separation of the right-hand SRBs aft attachment and the structural failure of the external tank. Aerodynamic forces broke up the orbiter.
The crew compartment and many other vehicle fragments were eventually recovered from the ocean floor after a lengthy search and recovery operation. The exact timing of the death of the crew is unknown; several crew members are known to have survived the initial breakup of the spacecraft. The shuttle had no escape system, and the impact of the crew compartment with the ocean surface was too violent to be survivable.
The disaster resulted in a 32-month hiatus in the shuttle program and the formation of the Rogers Commission, a special commission appointed by United States President Ronald Reagan to investigate the accident. The Rogers Commission found NASA's organizational culture and decision-making processes had been key contributing factors to the accident.[1] NASA managers had known contractor Morton Thiokol's design of the SRBs contained a potentially catastrophic flaw in the O-rings since 1977, but failed to address it properly. They also disregarded warnings (an example of "go fever") from engineers about the dangers of launching posed by the low temperatures of that morning and had failed in adequately reporting these technical concerns to their superiors.
What Rogers did not highlight was that the vehicle was never certified to operate in temperatures that low. The O-rings, as well as many other critical components, had no test data to support any expectation of a successful launch in such conditions. Bob Ebeling from Thiokol delivered a biting analysis: "[W]e're only qualified to 40 degrees ...'what business does anyone even have thinking about 18 degrees, we're in no man's land.'"[2]
As a result of the disaster, the Air Force decided to cancel its plans to use the Shuttle for classified military satellite launches from Vandenberg Air Force Base in California, deciding to use the Titan IV instead.
Many viewed the launch live because of the presence of crew member Christa McAuliffe, the first member of the Teacher in Space Project, who would have been the first teacher in space. Media coverage of the accident was extensive: one study reported that 85percent of Americans surveyed had heard the news within an hour of the accident. The Challenger disaster has been used as a case study in many discussions of engineering safety and workplace ethics.
Each of the two Space Shuttle Solid Rocket Boosters (SRBs) that comprised part of the Space Transportation System was constructed of seven sections, six of which were permanently joined in pairs at the factory. For each flight, the four resulting segments were then assembled in the Vehicle Assembly Building at Kennedy Space Center (KSC), with three field joints. The factory joints were sealed with asbestos-silica insulation applied over the joint, while each field joint was sealed with two rubber O-rings. (After the destruction of Challenger, the number of O-rings per field joint was increased to three.)[3] The seals of all of the SRB joints were required to contain the hot high-pressure gases produced by the burning solid propellant inside, forcing it out the nozzle at the aft end of each rocket.
During the Space Shuttle design process, a McDonnell Douglas report in September 1971 discussed the safety record of solid rockets. While a safe abort was possible after most types of failures, one was especially dangerous: a burnthrough by hot gases of the rocket's casing. The report stated that "if burnthrough occurs adjacent to [liquid hydrogen/oxygen] tank or orbiter, timely sensing may not be feasible and abort not possible", accurately foreshadowing the Challenger accident.[4]Morton Thiokol was the contractor responsible for the construction and maintenance of the shuttle's SRBs. As originally designed by Thiokol, the O-ring joints in the SRBs were supposed to close more tightly due to forces generated at ignition, but a 1977 test showed that when pressurized water was used to simulate the effects of booster combustion, the metal parts bent away from each other, opening a gap through which gases could leak. This phenomenon, known as "joint rotation," caused a momentary drop in air pressure. This made it possible for combustion gases to erode the O-rings. In the event of widespread erosion, a flame path could develop, causing the joint to burstwhich would have destroyed the booster and the shuttle.[5]
Engineers at the Marshall Space Flight Center wrote to the manager of the Solid Rocket Booster project, George Hardy, on several occasions suggesting that Thiokol's field joint design was unacceptable. For example, one engineer suggested that joint rotation would render the secondary O-ring useless, but Hardy did not forward these memos to Thiokol, and the field joints were accepted for flight in 1980.[6]
See the original post:
Space Shuttle Challenger disaster - Wikipedia, the free ...
- Armadillo’s Level 2 LLC attempt coming soon? - November 8th, 2009 [November 8th, 2009]
- Decisions, decisions - November 8th, 2009 [November 8th, 2009]
- Armadillo versus the weather - November 8th, 2009 [November 8th, 2009]
- Photos from Armadillo’s Saturday flights - November 8th, 2009 [November 8th, 2009]
- Armadillo Level 2 Flight 1 - November 8th, 2009 [November 8th, 2009]
- Meanwhile, elsewhere in the LLC race - November 8th, 2009 [November 8th, 2009]
- Masten gets halfway there - November 8th, 2009 [November 8th, 2009]
- Xombie photos (finally!) - November 8th, 2009 [November 8th, 2009]
- Is the media clowning around? - November 8th, 2009 [November 8th, 2009]
- Galactic Suite “on schedule”? - November 8th, 2009 [November 8th, 2009]
- Scientist Guest Column: Using Commercial Suborbital Spacecraft for Microgravity Chemistry Research - November 8th, 2009 [November 8th, 2009]
- Building Spaceport Infrastructure: An Overview of the STIM-Grants Program - November 8th, 2009 [November 8th, 2009]
- Five Years After SpaceShipOne’s Historic X PRIZE Flight, New Challenges Await - November 8th, 2009 [November 8th, 2009]
- Masten Space Systems Makes Successful Flights to Qualify for $150K NASA Lunar Lander Prize Level 1 - November 8th, 2009 [November 8th, 2009]
- Distinguished Former NASA Astronauts Endorse Commercial Spaceflight in Wall Street Journal Op-Ed - November 8th, 2009 [November 8th, 2009]
- NASA Chief Praises Commercial Spaceflight, Suborbital Science, & Innovation Prizes in Speech - November 8th, 2009 [November 8th, 2009]
- CSF Welcomes Strong Support for Commercial Human Spaceflight in White House Panel’s Report - November 8th, 2009 [November 8th, 2009]
- Commercial Spaceflight Federation President Bretton Alexander Appointed to the NASA Advisory Council - November 8th, 2009 [November 8th, 2009]
- In November 5th Public Ceremony, NASA to Award $1.65 Million In Prizes for Commercial Spaceflight Successes - November 8th, 2009 [November 8th, 2009]
- CSF Congratulates Winners of NASA’s $2 Million Lunar Lander Challenge - November 8th, 2009 [November 8th, 2009]
- Welcome to the NewSpace Journal - December 13th, 2009 [December 13th, 2009]
- Some things even Virgin can’t control - December 13th, 2009 [December 13th, 2009]
- While you’re waiting for the rollout… - December 13th, 2009 [December 13th, 2009]
- SpaceShipTwo rollout: initial impressions - December 13th, 2009 [December 13th, 2009]
- A couple of pics - December 13th, 2009 [December 13th, 2009]
- SpaceShipTwo slideshow - December 13th, 2009 [December 13th, 2009]
- The Virgin party’s aftermath - December 13th, 2009 [December 13th, 2009]
- Investment in Commercial Spaceflight Grows to $1.46 Billion, Updated Industry Study Reveals - December 13th, 2009 [December 13th, 2009]
- Former Astronaut-Astronomer, Sam Durrance, Joins the CSF Suborbital Researchers Group - December 13th, 2009 [December 13th, 2009]
- Commercial Spaceflight Federation Announces Creation and Initial Membership of Spaceports Council - December 13th, 2009 [December 13th, 2009]
- CSF President Bretton Alexander Testifies Before House Science Committee on Spaceflight Safety - December 13th, 2009 [December 13th, 2009]
- CSF Vice-Chairman Jeff Greason Testifies Before House Transportation and Infrastructure Committee on Commercial Spaceflight Regulation - December 13th, 2009 [December 13th, 2009]
- Virgin Galactic Unveils SpaceShipTwo - December 13th, 2009 [December 13th, 2009]
- So that’s why Aabar invested in Virgin? - December 15th, 2009 [December 15th, 2009]
- More about the Virgin rollout aftermath - December 17th, 2009 [December 17th, 2009]
- Space tourism as “the final undiscovered frontier”? - December 17th, 2009 [December 17th, 2009]
- Orion Propulsion acquired - December 17th, 2009 [December 17th, 2009]
- Spaceport America developments - December 18th, 2009 [December 18th, 2009]
- XCOR wins a major customer - December 19th, 2009 [December 19th, 2009]
- Centennial Challenges, Spaceport Infrastructure Grants, and Suborbital Science to Receive Funds from NASA and FAA - December 22nd, 2009 [December 22nd, 2009]
- Video tour of Spaceport America - December 24th, 2009 [December 24th, 2009]
- Virgin’s web traffic planning - December 24th, 2009 [December 24th, 2009]
- List of Speakers Announced for the Next-Generation Suborbital Researchers Conference in February - December 31st, 2009 [December 31st, 2009]
- Popular Science Features Commercial Spaceflight on January Cover, Discusses NASA Partnerships - January 4th, 2010 [January 4th, 2010]
- Aviation Week honors the “Space Entrepreneur” - January 5th, 2010 [January 5th, 2010]
- “The Space Entrepreneur” Named by Aviation Week Magazine As Its 2009 Person of the Year - January 5th, 2010 [January 5th, 2010]
- Additional notes about Olsen’s book - January 6th, 2010 [January 6th, 2010]
- Registration deadline approaching for suborbital science conference - January 8th, 2010 [January 8th, 2010]
- NASA Deputy Administrator Lori Garver to Keynote the Next-Generation Suborbital Researchers Conference in February - January 11th, 2010 [January 11th, 2010]
- Cecil Field gets spaceport license – but will anyone use it? - January 12th, 2010 [January 12th, 2010]
- Training begins for suborbital scientist-astronauts - January 12th, 2010 [January 12th, 2010]
- First Class of Suborbital Scientist-Astronauts Successfully Complete NASTAR Training Program - January 14th, 2010 [January 14th, 2010]
- Is “space tour guide” in your professional future? - January 17th, 2010 [January 17th, 2010]
- What can Florida, Indiana, and others learn from Oklahoma? - January 17th, 2010 [January 17th, 2010]
- Virginia wants money, New Mexico wants laws - January 21st, 2010 [January 21st, 2010]
- Commercial Spaceflight Federation Responds to the Aerospace Safety Advisory Panel’s 2009 Annual Report - January 21st, 2010 [January 21st, 2010]
- CSF Statement on NASA’s Anticipated Announcement of a $6 Billion Commercial Crew Program and NASA Budget Increase - January 29th, 2010 [January 29th, 2010]
- CSF Welcomes New NASA Human Spaceflight Plan, Congratulates Commercial Crew Development Winners - February 1st, 2010 [February 1st, 2010]
- NASA Unveils Commercial Human Spaceflight Development Agreements and Announces $50 Million in Seed Funding for Commercial Crew - February 3rd, 2010 [February 3rd, 2010]
- James Cameron Endorses Commercial Spaceflight, New NASA Plan - February 4th, 2010 [February 4th, 2010]
- Newt Gingrich and Bob Walker Endorse Obama’s New NASA Plan, Urge Bipartisan Support - February 13th, 2010 [February 13th, 2010]
- Blue Origin proposes orbital vehicle - February 18th, 2010 [February 18th, 2010]
- CSF Announces New Research and Education Affiliates Program, Initial Participating Universities - February 18th, 2010 [February 18th, 2010]
- CSF Welcomes Historic NASA Commitment of $75 Million for Commercial Suborbital Flights, Payloads - February 18th, 2010 [February 18th, 2010]
- Suborbital vehicle development updates - February 19th, 2010 [February 19th, 2010]
- Other conference announcements - February 21st, 2010 [February 21st, 2010]
- Bigger prizes to come? - February 23rd, 2010 [February 23rd, 2010]
- Gov. Bill Richardson Endorses Commercial Spaceflight, Obama’s New NASA Plan - February 23rd, 2010 [February 23rd, 2010]
- Over 250 People Attend Next-Gen Suborbital Researchers Conference, 2011 Meeting Planned for Florida - February 24th, 2010 [February 24th, 2010]
- Boston Globe, Nature, New York Times Editorial Boards Among Others Welcoming New NASA Plan - February 25th, 2010 [February 25th, 2010]
- Commercial Spaceflight Federation Commends New Mexico for Passage of Key Liability Legislation - March 2nd, 2010 [March 2nd, 2010]
- Burt Rutan’s BigThink - March 3rd, 2010 [March 3rd, 2010]
- Brief notes: Soyuz, Virgin, and… iCarly? - March 5th, 2010 [March 5th, 2010]
- Commercial Spaceflight Federation 2009 Annual Report Highlights Industry Progress - March 8th, 2010 [March 8th, 2010]
- SpaceShipTwo flies, on schedule - March 23rd, 2010 [March 23rd, 2010]
- SpaceShipTwo captive carry flight video - March 23rd, 2010 [March 23rd, 2010]
- Over the Mojave Desert, Suborbital Vehicles Take Flight - March 28th, 2010 [March 28th, 2010]
- See WK2 and SS2 fly in New Mexico this October - March 29th, 2010 [March 29th, 2010]
- SA10: Commercial RLV Technology Roadmap update - April 9th, 2010 [April 9th, 2010]
- An evolving Armadillo - April 11th, 2010 [April 11th, 2010]